Тёмный

No spark on lawn mower engine - Ignition coil replacement 

MegaSafetyFirst
Подписаться 68 тыс.
Просмотров 58 тыс.
50% 1

This video explains the replacing the ignition coil on a push lawn mower so you can do it yourself.
First we test if the spark plug still shows a spark when trying to start the small engine. Since this is not the case, we check the kill-switch wire and make sure it is connected correctly.
Removing the old ignition coil is very easy. When installing the new ignition coil, make sure to rotate the flywheel into a position where the magnets on the flywheel face the ignition coil.
I am using a folded piece of paper to adjust the correct gap between ignition coil armature and magnet. After tightening the screws of the ignition coil, ensure that the flywheel can still rotate freely. Then reassemble the mower.
At the end we check again if the spark plug is able to develop a spark, which is the case now.
We have fixed our lawn mower successfully.

Опубликовано:

 

21 окт 2024

Поделиться:

Ссылка:

Скачать:

Готовим ссылку...

Добавить в:

Мой плейлист
Посмотреть позже
Комментарии : 42   
@nathanselmer1082
@nathanselmer1082 2 года назад
Good easy understanding video
@snowboardingable
@snowboardingable 3 года назад
Great video by the way!
@hepeng2627
@hepeng2627 2 года назад
thanks share this video
@harrygrimley4352
@harrygrimley4352 2 года назад
Very nice. Thanks
@jackbloznowski5429
@jackbloznowski5429 3 года назад
Actually the thin wire is for your kill switch. Make sure the cable/lever mechanism on the handle is pulling the ground contact away from that wire contact when you pull down the handle. When the handle is released, you are grounding that wire to ground, stopping the engine.
@frankcontreras5928
@frankcontreras5928 2 года назад
Thank you...
@jerrycannon6940
@jerrycannon6940 4 года назад
Suppose coil are good but still no spark?
@th3d4v1d14n
@th3d4v1d14n 4 года назад
I replaced the ignition coil on my lawn mower, but the new one failed in two weeks. What is the problem?
@kalamelliel
@kalamelliel 4 года назад
Great video. Do you know what the problem is if my lawn mower doesn’t stop once it get started?
@josephwalter662
@josephwalter662 4 года назад
Kill switch may not be grounded properly coming off of the ignition coil.
@red666A
@red666A 5 лет назад
Good work. How about grass trimmer? Is there ignition coil in there too?
@investingwitha-aron8055
@investingwitha-aron8055 4 года назад
Is it possible to have a bad ignition coil and being able to start the mower after 15-20 pulls. I am having a hard time starting the mower. The wire is a little loose in the boot. I end up having to use wd-40 in the spark plug hole and reattach spark plug. I can usually get it to work after about 15-20 pulls. After it starts, it runs well. The carberetor is all cleaned out, so no longer have that issue.
@Gear1993Head
@Gear1993Head 4 года назад
Guarentee your engine is low on compression
@topflight2358
@topflight2358 4 года назад
my wire came out from the coil, not the spark plug side , can i remove pull rope / cover to get to the coil and just push it back in ??
@MegaSafetyFirst
@MegaSafetyFirst 4 года назад
That should be fine as long as it can still be tightened.
@randomtech6115
@randomtech6115 5 лет назад
I had no idea the black wire was for killswitch.
@glen3925
@glen3925 3 года назад
Yeah it basicly transfers the electricity to ground that way the power can't be sent to the spark plug stopping the engine
@dcamp78Utube
@dcamp78Utube 4 года назад
what if you replace the coil exactly as you did and STILL no spark?
@mustafafadel2035
@mustafafadel2035 4 года назад
Try changing the spark plug
@mustafafadel2035
@mustafafadel2035 4 года назад
Or sanding the magnets on the crack shaft if the spark plug wasn’t the problem
@redraif
@redraif 4 года назад
@@mustafafadel2035 Mower had no start issue. It has a new filter and carb, fresh no ethanol gas. Checked plug, it was damp, so it was getting gas, but looked old. I replaced the spark plug with a new one & it fired up once, mowed yard. 5 days later was dead again. I checked and no spark. I replaced the coil and verified kill wire was installed, but still no go. Thanks for that tip. I will try this.
@mustafafadel2035
@mustafafadel2035 4 года назад
redraif also check if the kill wire has dirt on it if it does make sure you clean it
@redraif
@redraif 4 года назад
So I carefully sanded any rust off the flywheel magnets, so its smooth again. Nothing crazy, just a light wire brushing. I decided to go ahead and just replace the kill wire with a new one to be sure. Reinstalled the new coil and new spark plug and still nada. I looked at the wires on the key on/off & seat cut off. All appear in good shape. All three were attached at their junction stud. I'm at a loss. I guess I will remove the new coil and test it just for hee-haws next. :(
@kingyt5400
@kingyt5400 5 лет назад
Dude I came from your spoiled milk video and I just took a spoon and little bit of milk and as I drank it I went to washroom and vomited
@drivewaygarage1561
@drivewaygarage1561 4 года назад
Good video
@jordanhudson5075
@jordanhudson5075 5 лет назад
What if your reading on your coil is 10.4
@snowboardingable
@snowboardingable 3 года назад
Those shoes tho Welcome to green stains and dad land
@newsyoucanuse8213
@newsyoucanuse8213 4 года назад
ty
@dildarhussain6594
@dildarhussain6594 Год назад
Coil is good but no spark
@ronaldpeters4390
@ronaldpeters4390 Год назад
Replace coil and plug still no spark.
Далее
What’s your height?🩷🙀💚
00:59
Просмотров 3,5 млн
Watching This On Loop ♾️
00:32
Просмотров 10 млн
FIX Engine Surging on any small engine QUICKLY
16:03
Просмотров 1,5 млн
How to Replace Ignition Coil on John Deere X320 Mower
15:55
No spark diagnosis and Explanation (GY6)
16:50
Просмотров 122 тыс.