Fuel pump removal: 30 to 60 minutes ($225 / $400 / $590) In this video I pulled the fuel pump from a Volvo 960 wagon. This process will be about the same when accessing the fuel sending unit in all of the rear wheel drive Volvo's.
+Robert DIY Hello Robert my 960 starts runs rough now it wont start do you think it is my fuel pump it was running fine till I went to gas station put gas in then it didnt turn over well it does but its like stumbling then shuts down
Thank u for ur much wisdom, I have a 2002 Winstar.....that is having problems being smogged I need to replace the o2 sensor n apparently .check engine light is not coming on what type of problems will I run into and pulling this you can contact me back thank you
Yes, replaced the o 2 sensor and replaced the check engine light bulb, now driving to clear code,no check engine light. It still says O2 sensor problems... Too many tickets now... Seeking out other help... Thanks... Oh found wires coming out fuse box to under hood,lol
Hello Robert,do you know,and can you provide the detail,I need to replace the head gasket to my s90 1998 181 Hp 132 Kw Engine.at what Torque K gm do I start to tighten the bolts, and at what K gm do I finish. Thank you!
Hi Robert I am have a problem with the car is run for a long time and then it will not start .I have a 960 Volvo 1996 . We check the start any help .Thank Betty Jean
@@RobertDIY Thank you ! My wife explained the problem wrong. This is a starter circuit problem . Much of the time and for days at a time the starter starts the car completely normally . Then suddenly ( unrelated to warm or cold engine after 8 hour work shift etc. ) the starter solenoid will just click but the starter won't engage and turn over the engine, leaving you stranded. Then after a few days of rest (idle neglect) it will return to normal operation I have now had a shop remove the starter and I personally have disassemble and reassembled the starter . ( cleaning and lubing , brushes are ok commutator fine sandpapered etc.) And I have bench tested the starter . It seem fine. The shop I had install an after market new $67.00 ebay starter . The shop said it would spin but not engage. Now I want to have them put back the original starter to see how it preforms if the intermittent problem is gone. Thanks for your kind help with this matter Robert Thomas
Does anyone know where the smaller of the two vent hoses located to the immediate left of the large metal filler neck hose goes? I didn't disconnect mine but I found it just laying there......at 1:29 in the video that hose is running across the top of the large plastic securing ring.......I see no other hoses that it might connect to.....thanks
I got a 95 960 volvo put new fuel pump in drain bad gas then put new filter on now it won't pump gas threw it but it was before I changed filter any suggestions would help thanks
@RobertDIY pump cuts on just no gas coming out I took it out made sure nothing was broken and it ain't put it back in .nothing coming outta tank to rail its not even reaching filter
Will that sending unit fit a 1990 740 GL? I found a 1993 960 at Pull-A-Part only been there a month with just 44000 miles on it. Someone has already got the transmission
You're quick! That's awesome, thank you! I recently purchased a 98 v90 that stalls usually after coming to a stop. RPMs drop and I have to goose the pedal to keep it alive or it shuts down. Usually starts back up after a couple cranks.
@@RobertDIY no it does not,im trying to pull my quick discoonect fuel line but it wont pull off,im pulling up on the sleeve and line but it isnt working i think im doing it wrong
Robert DIY my 95 960 was sluggish , the coil pack wires were brittle shit... u seen em.... i cut snd may have wired wrong but have according to schematic, and it wont strt everything fuel is wirimg ir no signal according to self code checks cnt check ignition codes