No video :(

How To Change Transmission Oil Aisin Tf-80 / AM6 Citroen DS5 (DS3, DS4, C4, Peugeot 3008, 5008, etc)

Подписаться 705

Просмотров 65 тыс.

50% 1

READ DESCRIPTION - IMPORTANT INFORMATION
How To Change Transmission Fluid / Oil In Citroen DS5
The Aisin Tf-80 is used in a variety of vehicles, some of which are listed below. The method will be very similar if not identical.
Citroen: DS3, DS4, C4, C5, C6
Peugeot: 307, 308, 407, 408, 508, 607, 3008, 5008
Full List Of Other Brands At Bottom Of Description Box, they include Volvo, VW, Toyota, Mazda and others.
This is for the Aisin BVA AM6C type transmission. Please check which transmission you have. It may or may not be similar. The computer Diagbox steps shown in the video aren't a strict requirement, but they will ensure the best improvement in the gearbox after service.
Part Numbers:
O-Ring, PSA: 220945 , GM: 93183574
Crush Washer, PSA: 220923 , GM: 93183578
CAUTION : The oil type "AW-1" in AT6 and AM6 gearboxes with engine version Euro 5 is specific and cannot be replaced with oil type "JWS 3309".
Dry gearbox oil capacity : Approximately 7 litres.
Type of oil required (Red) :
EURO 5 engine : AW-1 oil
EURO 4 engine : JWS 3309 ESSO oil
Volume of oil remaining after draining : Approximately 4 litres.
Quantity of oil to be replaced : Approximately 3 litres.
5. To Check the oil level
Prior conditions :
Vehicle level
Check that the gearbox is not in downgrade mode
Remove the filler plug (3)
Add 0.5 additional litres of oil in the gearbox
Apply the brakes firmly and move the lever through the various selector positions
Gear lever in position "P"
Engine running at idle
Oil temperature 60°C (+ 8 ; - 2 °C) (Measurement of the parameters using diagnostic equipment)
Remove the oil level plug (2).
5.1. Stream of oil then reducing to a sequence of drips
Refit the oil level plug (2).
5.2. Sequence of drips or nothing
Refit the oil level plug (2).
Stop the engine.
Add 0.5 additional litres of oil in the gearbox.
Repeat the top-up procedure.
N.B. : The level of oil is correct when the stream of oil becomes drop by drop.
Refit the oil level plug (2) (equipped with a new seal).
5.3. Check the oil level (continued)
Refit :
The oil filler plug (3) (equipped with a new seal)
The protective panel under the engine
The air filter housing
Too high a fluid level can cause :
Overheating of the fluid
Fluid leaks
Too low a level causes destruction of the gearbox.
FULL LIST OF VEHICLES WITH THIS TRANSMISSION BELOW:
The Fluid change procedure should be very similar across all, but I take no responsibility for differences. Check Yourself!
BMW/MINI
2014-2020 i8
2015-present 225xe Active Tourer (F45)
2020-present X1 xDrive 25e (F48)
2020-present X2 xDrive 25e (F39)
2014-2017 (F56/55)
2015-2017 Clubman (F54) with 3 cylinder engines (B37 and B38)
2016-2017 Countryman (F60) with 3 cylinder engines (B37 and B38 FWD)
Alfa Romeo
2005-2011 159
2005-2010 Brera
2006-2010 Spider
Fiat
2005-2011 Croma
2012-2019 500
Lancia
2008-2014 Delta
Ford
2005-2007 Five Hundred
2006-2012 Fusion (US)
2007-2014 Mondeo MkIV 2.3 160 PS Petrol and 2.0 TDCi Diesel
2006-2014 Galaxy 2.3 118kw / 160PS Petrol (as standard gearbox)
Lincoln
2006 Zephyr
2007-2012 MKZ
Mercury
2005-2010 Milan
2005-2007 Montego
Cadillac
2005-2010 BLS
2009-2016 SRX II
Chevrolet
2008-2016 Cruze
Opel / Vauxhall
Astra
Vectra
Signum
Zafira
2008-2017 Insignia
2014-2017 Meriva
Saab
2006-2014 9-3 II (FWD & AWD)
2013-2014 9-3 III
2010-2012 9-5 II
Hyundai
2006-2014 Veracruz
Jaguar
2007-2009 X-type
Land Rover
2006-2014 Freelander 2
2011-2013 Range Rover Evoque
Mazda
2005-2008 6 I
2006-2012 CX-7
2006-present CX-9
2006-present MPV III
2007-2012 6 II
Citroën
C4
C5
C6
C8
DS3
DS4
DS5
2010-2016 Jumpy
C-Elysée
Peugeot
2006-2008 307
2014-2018 308
2005-2010 407
2010-present 408
2011-2018 508
2005-2010 607
2008- 3008
2009- 5008
2010-2016 Expert
Renault
2005-2009 Vel Satis
2006-2010 Espace
Suzuki
2014-present Vitara (FWD & AWD)
2015-present Baleno
2017-present Swift
2017-present SX4 S-Cross
Toyota
2006-2008 Previa (V6)
2007-2018 Camry
2007-2017 Aurion (V6)
2007-2012 Blade (V6)
2007-2013 Mark X Zio (V6)
2008-2016 Highlander
2008-2017 Alphard (V6)
2008-2018 Avalon
2008-2018 RAV4
2009-2017 Venza
2011-2016 Sienna
2017 ProAce
Lexus
2007-2018 ES350
2010-present RX (350 older models, 200t/300 new models)
2015-present NX200t (300 2018-present)
Lotus
2012 Evora (IPS)
2022-Emira (V6)
Scion
2011-2016 tC
Audi
2003-2013 A3
2015-2018 Q3
Škoda
Octavia
Rapid (India, 2019 improvement)
Volkswagen
2003-2010 Transporter
2007 Jetta
2009-2017 Tiguan
2012-present Passat (NMS)
2019-present Polo (MK5) (India)
Volvo
2005-2014 XC90 (FWD & AWD)
2006-2009 S60 (FWD & AWD)
2006-2008 V70 II (FWD & AWD)
2006-2008 XC70 (AWD)
2007-2016 S80 II (FWD & AWD)
2008-2016 V70 III (FWD & AWD)
2008-2016 XC70 II (FWD & AWD)
2009-2017 XC60 (FWD & AWD)
2011-2018 S60 II (FWD & AWD)
2016-2017 S90 (FWD)
2011-2018 V60 (FWD & AWD)
2011-2012 S40 II (FWD)
2011-2012 V50 (FWD)
2011-2013 C30 (FWD)
2011-2013 C70 II (FWD)
2012-2014 V40 II (FWD)

Опубликовано:

21 авг 2024

Ссылка:

Скачать:

Готовим ссылку...

Добавить в:

Мой плейлист

Посмотреть позже

Комментарии : 88

@duncanbooth7432 11 месяцев назад

Excellent clear instructions. Internet is a minefield you have to pick your way through. 100 ways of doing every job but 99 are BS! Stumbled on yours after many blind alleys, most had even got the make of gearbox wrong. Had to remove the air box to luckily find the stickers which were still attached. Great job. Any more videos on Citroen C5 VTX plus 2007 2.2 diesel auto would be greatly appreciated!

@HeroRepairs 11 месяцев назад

Thanks so much for the feedback. I've been there myself so know exactly what you mean, and it's the reason I make these videos!

@brycechessum4684 11 месяцев назад

Im doing a 2.2 diesel 6 speed today any differences

@HeroRepairs 11 месяцев назад

@@brycechessum4684 If it's the AM6 then it should be the same

@geertvanbaelen1136 Год назад

Your explanation was a good help to me. Thank you

@LokosLhry 7 месяцев назад

Hi and thx for video, does this gearbox has any filter to change or separate hydrolic oil ?

@sahabanfawy-qc8di Год назад

It is necessary for the car to be afraid of the machine. I want to change it myself, and I want to know the type of oil. Very excellent video

@albertoascari2542 7 месяцев назад

I've filled mine from the breather cap and only later noticed after removing the actuator ECU there's a cap on top of the almost hidden transmission reservoir.. Any ideas if ive done damage ?

@abdelkrimbenghanem2960 8 месяцев назад

Excellent tuto 1000 fois bravo

@jamesgarson1058 4 месяца назад

Thanks so much, much appreciated will do that

@mikebrock1965 5 месяцев назад

This also applies to the Mazda CX-9. I changed mine at 75K miles and it looked like dirty motor oil and the transmission was shifting badly. I ran thru 12qts of Mobile One 3309 fluid and it shifts like new now.

@yakirVk 2 месяца назад

Hey thanks for rhe informative video i have a question does the EAT6 GEARBOX not take JWS3324 Oil?

@fatihtas3027 8 месяцев назад

Hello, my 2016 fiat tipo (356)1.6 e-torq vehicle has an Aisin TF-72sc transmission. Which oil do you recommend for transmission oil change?

@dmoreno1977 10 месяцев назад

Muy buen vídeo. Muchas gracias 👍

@akaitv6606 6 месяцев назад

So many cars have this transmission Mazda cx7 Peugeot 308 Toyota aurion Ford mondeo Volvo

@HeroRepairs 6 месяцев назад

Yep, check out my full list in the video description

@serginfiat 9 месяцев назад

Gracias👍

@teacherkwang8779 10 месяцев назад

Where I can buy the new filler plug , or part number ? I want to buy a new one to spares. Can you advice ? And ship to thailand.

@abdelkrimbenghanem2960 8 месяцев назад

PLEASE, faire nous un tuto sur la boite automatique citrôen berlingo merci.

@Blitz9287 2 месяца назад

I'm looking to get this done on my 2007 Citroën C5 with the AM6 gearbox. What would be a fair price to pay for this gearbox oil service so I know I'm not being ripped off. Thanks.

@HeroRepairs Месяц назад

It's hard to say as the difference between countries can be large, but I would guess that anything up to 400 euros is probably quite fair.

@19can84 5 месяцев назад

Thanks for video. I am planning to get my 308 t9 eat6 transmission oil changed but I am not sure if my mechanic has the equipment for the software adjustment. Do you have any idea what happens if the oil life meter not get resetted?

@oynamalan 3 месяца назад

it does not do anything different than the old oil you drained at best. Harsh engagements persists. Be sure to reset the oil wear counter and do the pre-alignment process exactly like in this video. AC On, cycle through gears, drain excess oil, you're good to go.

@jamesgarson1058 4 месяца назад

Can you tell me what year this car is and was it a sealed unit thanks

@albertoascari2542 8 месяцев назад

What's the quantity of Oil please..Is 75-80 OK

@HeroRepairs 8 месяцев назад

You must look at the fill cap to find the oil type, most likely AW-1. From memory a 4L bottle will be enough to comple this service.

@albertoascari2542 7 месяцев назад

I topped up in the breather cap after draining 3 lires off, then found the cap on the actuator reservoir later..It looked looked full in the actuator reservoir anyway...Not sure but I Dudbridge repressure it with diagbox

@enriquegonzalez2802 5 месяцев назад

Could someone tell me what oil to use (not OEM) for my Peugeot 2008 year 2015 with Automatic transmission box AL4? Thanks :)

@motorworld8255 3 месяца назад

Hi, does it fit the 8 speed automatic gearbox of the 2021 C4 Spacetourer ?

@jamesgarson1058 4 месяца назад

I have a 2015 Citroen c4 grand Picasso and my auto transmission unit is sealed but I have taken the filler plug off yet to see if my drain plug is the same as yours

@HeroRepairs 4 месяца назад

What do you mean sealed? No transmission should ever be sealed. There will be a way to drain and fill it, but the procedure may differ depending on what transmission you have.

@jamesgarson1058 4 месяца назад

@@HeroRepairs yes my transmission is sealed for life they tell you this at Citroen but my car is 9 years old and has done 130000 and the auto gears are taking a bit more time to change , you can check out the other videos where they tell you it’s sealed but that’s so you don’t touch it

@HeroRepairs 4 месяца назад

@@jamesgarson1058 Those are just lies the manufacturers tell you so they can reduce service costs. They absolutely do need servicing. There's no such thing as a lifetime fluid.

@chlyon Год назад

Got the 2012 6AT 308 156HP is it a recommended procedure to replace oil filter on a car of this age ? . Is thateasy enough to do ? . Cheers for the video

@HeroRepairs Год назад

Yes it is recommended. There are various transmissions that it might have so you will need to check which one it is and find the procedure.

@user-wt7ug1ec9o 10 месяцев назад

How to change if your gearbox is "sealed for life" ?

@chlyon 10 месяцев назад

@@user-wt7ug1ec9o I changed the oil basically there's a plug at the bottom of gearbox actually 2 of them one inside the other , undo those plugs and drainfluid into pan measure the amount of transmission fluid then either reinject that same amount of new fluid back into the transmission from the bottom with a "turkey baster oil suction device , or go uptop and find the bung up there , its probably hidden under the air cleaner .

@user-wt7ug1ec9o 10 месяцев назад

@@chlyonYes i know that. But how you gonna change gearbox oil filter?

@chlyon 10 месяцев назад

@@user-wt7ug1ec9o Some can some cant be easily be changed .

@zarakitube 7 месяцев назад

Same for Ssangyong Tivoli?

@NoName-ne6es 2 месяца назад

Hello friend, I have a 2017 C4 Picasso 1.6 HDi with a 88kW EAT6 gearbox, 185,000 km, and the oil didn't look bad at all. Today I changed the oil and about 2.5 liters leaked out of the gearbox, roughly estimated. Then I poured in new oil, and when I poured 2.3 liters, it started leaking at the oil gauge. I added another 0.2 liters and didn't pour anymore. Shouldn't this gearbox take 3 liters of oil? Should I have poured in 3 liters or not? And what could happen if I leave more oil in it? Tnx

@HeroRepairs 2 месяца назад

Follow the instructions in the video and it will be OK.

@NoName-ne6es 2 месяца назад

@@HeroRepairs tnx friend

@nissimh.casanova76 Год назад

Hello, how many kilometers recomended change the oil ? I have a peugeot 508 2021 225 gt line EAT8

@HeroRepairs Год назад

Every 60,000km

@user-zz2qi4kz6w 5 месяцев назад

Is engine should running ,while check oil level by the plug?

@HeroRepairs 5 месяцев назад

Yes

@salebasket 6 месяцев назад

Does the gearbox have an oil filter that maybe should be changed?

@galaktoza 6 месяцев назад

Yes, but it's in the transmission

@serginfiat Год назад

Aplica el procedimiento para gearbox asim AT6 6 marchas peugeot 208 gracias.

@NoName-ne6es 11 месяцев назад

I have a c4 picasso 1.6 hdi 88kw EAT6. Do I need a Diagbox diagnostic tool, i.e. can I use any that can show me the oil temperature? When new oil is put in, it is necessary to go through all stages: P, R, N, D and manual mode, is it necessary to change all 6 gears to manual, can I because my gearbox has 6 gears (EAT6)? I think this is not enough, the same thing should have been done at least 2 more times so that the percentage of new oil was around 87.5%, this way we only have 50% new oil, especially if it is about high mileage and the oil has never been changed. Thx for video

@HeroRepairs 11 месяцев назад

Any diagnostic tool that shows transmission oil temp will be fine, I just assume diagbox is what most Citroen/Peugeot owners have. Diagbox also lets you reset the oil degradation counter which is how the transmission adapts over time. Yes you must shift through P, R, N, D, and then manual shift as high as you can (I believe it will only let you got to 3rd). Remember to keep the brake applied so the wheels don't spin! Most people will opt to do this service once, then drive for 500-1,000km and repeat the service. After that point you start to get diminishing returns, and usually it's a bad idea to completely change all the oil at once. It should be fine from then on to just perform the service periodically, say every 30,000km?

@NoName-ne6es 11 месяцев назад

@@HeroRepairs I don't have a Diagbox, and it's too expensive for me to go to a PSA service (which doesn't do oil changes), and it's hard for me to find someone who has a Diagbox. I will see with my repairman if his software can do that. How important is it to reset the counter, what if I don't reset it? My car has 175,000 km and the oil has never been changed, what should I do: should I change only 3 liters of oil (that is, only the oil that runs out) or replace the entire oil (that is, 3 times for 3 liters each), because I did not understand this part very well: "Most people will opt to do this service once, then drive for 500-1,000km and repeat the service. After that point you start to get diminishing returns, and usually it's a bad idea to completely change all the oil at once." If I understand correctly, if the entire oil is replaced, there may be a problem with the operation of the gearbox? I've also heard from some people that I don't change anything for now because I can only get problems instead of improvements? Tnx

@HeroRepairs 11 месяцев назад

@@NoName-ne6es You can buy a diagbox clone yourself from ebay or aliexpress. Or if you can find a different type of scan tool that reads transmission temp then that should work. It is preferable to reset the oil wear counter, but not essential. Especially if you only change 3 litres at a time and drive it between services then I don't think it'll be an issue as the gearbox will adapt itself somewhat. The only danger is flushing out too much of the old fluid in one go, but by doing it 3 litres at a time you very likely won't have any issues. This is because old fluid can have clutch fibres etc floating in it which gives it added friction, sometimes on older transmissions the clutch packs have degraded and new oil can be "slippery". But like I say, do 3 litres then drive it for 1000km or so, then change another 3 litres. That is the most efficient way to do it, and still retains a little bit of friction from the old oil just incase.

@dawidbednarski5890 10 месяцев назад

@@HeroRepairs5:24

@albertoascari2542 8 месяцев назад

What oil type for this transmission please?

@user-fh7ik3wf8x 9 месяцев назад

Do you recommend changing the oil every 50,000 km?

@HeroRepairs 9 месяцев назад

Yes every 50-60,000km should be fine

@user-fh7ik3wf8x 9 месяцев назад

@@HeroRepairs thak you

@eddydayan2269 Месяц назад

Its necessary the computer software to perform a replacement?

@HeroRepairs Месяц назад

Ideally yes. You might get away with just doing 3L and the car will adapt itself over the next few hundred kms, but best practice is to tell it when you have changed the fluid.

@eddydayan2269 Месяц назад

How to do that which software I need?

@HeroRepairs Месяц назад

@@eddydayan2269 PSA Diagbox or a scanner that supports this car

@sahabanfawy-qc8di Год назад

السلام عليكم ورحمة الله وبركاته هو لازم العربيه تخش على الجهاز وياريت الرد شكرا

@HeroRepairs Год назад

Sorry but I cannot understand your question. Are you asking if the computer reset is necessary?

@sahabanfawy-qc8di Год назад

@@HeroRepairs It is necessary for the car to be afraid of the machine. I want to change it myself, and I want to know the type of oil. Very excellent video

@sahabanfawy-qc8di Год назад

هو لازم العربيه تخش على الجهاز

@user-fh7ik3wf8x 10 месяцев назад

Hi, i have a ciitroen grand c4 spaceturer eat8 which oil i have to use? Thanks

@HeroRepairs 10 месяцев назад

Look at the fill plug, it should say what type to use.

@user-fh7ik3wf8x 10 месяцев назад

@@HeroRepairs thanks, the procedure for the eat8 Is the same? The level must be done at 60°? Thanks a lot

@taiblatiftaiblatif724 Год назад

Can u share what type of atf oil u use?

@HeroRepairs Год назад

It depends on the car make and model. It should be written on the transmission fill plug on top of the transmission or maybe in the owners handbook. It will be either AW-1 oil, or JWS 3309 ESSO oil. Be careful because you must not mix the oil types or put the wrong oil in.

@paulosantana1200 Месяц назад

No filter ?

@HeroRepairs Месяц назад

@@paulosantana1200 The technical service manuals don't show a service method for one.

@afa140 Год назад

Hi. Volvo also uses this transmission, right?

@HeroRepairs Год назад

Correct, along with many other brands you can see here: en.wikipedia.org/wiki/AWTF-80_SC#Applications

@neilyoung5116 7 месяцев назад

Finally, someone who actually knows the correct method and what the fill level plug is for. Excellent tutorial

@joex9152 Год назад

What is the type of dlc connector and the name of the program?

@HeroRepairs Год назад

Diagbox which is for Citroën. Other brands have their own program. Sometimes a good obd scan tool can reset transmission adaptations.

@joex9152 Год назад

@@HeroRepairs you are such a good engineer

@joex9152 Год назад

@@HeroRepairs i want to communicate with you

@CitroenC5PlFacebook 29 дней назад

to nie wymiana oleju a dolewka do syfu , aisin zaleca tylko i wylacznie wymaine dynamiczna , w silniku tez wymieniasz tylko 2 l albo w frytkownicy ?? producent skrzyni nie przewiduje wymiany statycznej ...