✅Volvo S80 2.4 D5 Engine Swirl Flaps Removing & Solving 

Спасибо за твои видео 👍. Это тяжёлый труд! С наступающим новым годом!

Super Arbeit danke für das tolle Video hab den gleichen Volvo wie du auch und konnte mir ein paar Tipps😊

Awesome, thanks

You're wrong, not every D5 has swirl flaps. On my D5 biturbo, 205hp no swirl flaps at all...

do you have a video of the removal of the intake manifold?

😁i remooved mine too

you said the d4 has the problem solved, how about the 2013 D3, is it resolved on d3 as well?

Is the 2.4 D4 a better engine despite not having quite the performance?

With VIDA, how is disabling in the software of the swirl valves done? Do you have video how to do that?

What do you use to plug the hole?

Hi, you said that you are not going to replace them, you mean the Swirl Flaps? If they are still good, no reason for new once, right?

Are you removing swirl flaps altogether? Leaving holes open? And re programming ECU so it does not try to open and close?

Good afternoon... From UK.... I have a 2007 V70 2.4se sport. D5 engine. I replaced the actuator arm 6 months ago and now I have noticed oil weeping out. You mentioned in your video about locking down on somthing to stop the oil coming out before removing and replacing the swirl flaps and removing the carbon deposits. Maybe you have touched on something that is causing my problem.... Could you please elaborate more on that specific section of your video. It was 1.50/1.57 minutes into your video?..... Thanks 👍

Thank you, usually after how many Km this happen? why you need to reprogram the swirl flap, the electronic control unit ... and how you do it?

Man arī eļļu sulo no gala. Kā tieši to pasākumu noslēgt galā? Kāja jau sen nolūzusi un pazudusi, braucu ar klapēm ciet, tagad vaļā un vieglāk, patīkamāk iet.

Hello, i have few questions. If remooving egr and dpf, can flaps be remmoved or just reprogrammed ? Also is it better to change new set of flaps ? What is advantage of remooving them ? Is it just loose some power on small revs, start driving or it is also rekated to better performance, oil, turbo lubrication, injectors ? I mean many discusions on them..Also some say leave egr, leave new flaps, just drill holes trough dpf. So what is your advice ? I understand purpose of egr, not just no black shocolate in intake, but regarding cooler intake temperature, and regarding nox gases, but then again..bad for turbo, oils, lubrication, performane, dpf clogs. So in my opinion remooving dpf and egr reorogram and sealing is good for engine, performance, etc, good for rurbo, and so on. But how regarding swirls then in this case if doong chiotune uograde. Also regarding engine oils in both cases. 0/w30 or 5/w30 ? Remonded 0w30 for colder climate, but if miage about 300 000km then maybe 5w30 better and if no egr no dpf. Better in cold climate start, but bad lubrication of turbo etc if5w30 ? What would be your advice ?:) Thanks in advace

How much for removing them and how much does this cost?

Clean out the soot, install new swirl flaps, fix the injectors and you're good to go for another 300000 km. THAT much of a soot buid-up indicates injectors problems, so that's where you should start with fixing that engine. Clogged swirl flaps generate even more soot, as a feedback loop so the result becomes the reason. If you're about to remove swirl flaps form the ecu, remove egr and dpf as well, WITHOUT writing a new map and WITHOUT fixing injectors, you get back to 2.5tdi era economicaly and ecologicaly wise. Or just buy a petrol engine car... ?? Aw, you're a moding company. That explanes a lot...

Sveiki!cik maksā izņemt un izprogrammēt swirl flapus ar visu darbu? Egr vārstu arī interesē likvidēt.volvo v70 2008g 136kw D5.

whats the point of removing them flaps? Not better to clean this and reinstall the flaps? Is this not better to clean and buy a part to replace?

Cik tāds prieks izmaksā? + chiptuning

hello,i have the same problem with the same car ,must to reprogramate the "flaps unit"?sorry my english

What problems do swit flaps cause like that ??

Par defaut les clapets sont en position fermée? au démarrage ils s ouvrent pendant le ralenti ?

T1 and T2 dont have swirl flaps.

Megashit 😯

Aaaaand where's the solving part ? I mean for DUIs.

What are the symptoms ?

Low-quality engine oil.

STAY AWAY FROM DIESEL CARS