Chain maintenance-riders rarely do it as frequently as they should, and often don’t do it right. In this video from the MC Garage, we’ll show you how to determine when your chain needs lubing and then demonstrate the easiest and most effective way to clean and lubricate your chain. Also in this video: The inner workings of the modern “sealed” motorcycle chain, and an explanation of why it only takes a little chain lube (applied to the right area!) to keep your drivetrain happy.
--
What Do I Need To Lubricate My Motorcycle Chain?
Even before you start gathering your tools to clean and lubricate your chain, you need to determine if your chain needs it. A good rule of thumb is that you should be lubricating your chain every third or fourth time that you fill up your gas tank. If you live in a place where it rains often, we suggest tightening this schedule. Check your chain and sprockets for rust and wear and determine if it is time to change them out.
While checking out your chain and sprockets, go ahead and read your service manual for how much slack your chain should have. Depending on your manufacturer, this measurement might be taken on the kickstand or while the bike is vertical. If you find that your chain is out of spec, go ahead and adjust it. If you have a single-sided swingarm that needs adjusting, we have you covered.
Now that you’ve determined it’s time for a lube, go ahead and gather what you need. At the very minimum, you’ll need some clean rags, an o-ring safe chain cleaner, a chain cleaning brush, chain lube, a piece of cardboard or thick paper to protect from overspray, and latex gloves to keep your hands clean.
Get The Rear Wheel Off Of The Ground
If you’re one of the lucky few who have a motorcycle equipped with a center stand, go ahead and skip over this section. If you’re not, we suggest that you find or purchase a rear stand, because if not, you’ll only be able to lubricate and wipe down a small section of the chain at a time. You could also buy a motorcycle jack, as long as your motorcycle’s rear wheel is able to spin freely.
Clean Your Chain And Sprockets
You’ve identified that you need to lubricate your chain, but what about cleaning it? It is recommended that you get dirt and grime off your chain before you apply more lube, but sometimes you cannot. If you’re at home, not only a transcontinental trip, you should clean your chain-check out our in-depth guide on how to clean your chain. Cleaning your chain will make it, and your sprockets, last longer.
A staple of many garages, WD-40 is effective at keeping your chain clean, with a little elbow grease and a good wipe down after application. Do not use it as a lubricant though. We repeat, WD-40 is not a lubricant. It might make door hinges less squeaky, but it will not be sufficient enough for your rollers and bushings.
Apply New Lubricant To The Chain
Believe it or not, but there is a right way to apply lubricant to your chain. Also, to echo what we said before, WD-40 should not be used as a motorcycle chain lubricant. Go ahead and save yourself the headache and purchase a motorcycle-specific chain lubricant. To lubricate your chain correctly, you should spray the lube on the top of the chain below the swingarm. Kick your bike into neutral, rotate the rear tire with one hand, and spray the lube on the top of the rollers and plates with the other. That handy piece of cardboard will protect your tire and wheel from any splash or overspray.
Another tip: As tempting as it might be, do not turn on your motorcycle and allow your engine to run in gear while you spray the lubricant on your chain. This is a good way to get the can, spray nozzle, or even your finger trapped in the chain and cut off. Just don’t do it.
Read the step-by-step on Motorcyclist: www.motorcyclistonline.com/ho...
Chain Cleaner - amzn.to/2JL2lx8
Chain Lube - amzn.to/2E7mQRi
Tirox 360 Chain Brush - amzn.to/2JGMu30
Motion Pro Chain Brush - amzn.to/2E5MNR6
When should you lubricate your chain? (0:15)
What chain lube should I use? (0:34)
What do I need to lube my chain? (0:50)
How do I clean my chain? (1:15)
Chain lubrication tips (1:43)
Subscribe: ru-vid.com...
Motorcyclist Shirts: teespring.com/stores/motorcyc...
Shop Products We Use: www.amazon.com/shop/motorcycl...
See more from us: www.motorcyclistonline.com/
23 окт 2015
