KT196 Go Kart - HIPA Carb Replacement - Small Engine Saturday

Подписаться 90 тыс.

Просмотров 14 тыс.

50% 1

HIPA Store ▶ bit.ly/3W3RbG5
Carb ▶ amzn.to/3j1kUkq
#hipaeasyfix #hipadiyrepair
Ranchero302me ▶ ru-vid.com?sub...
This Coleman KT196 go kart was sitting for about a year after being abused by my neighbor's kid, the carburetor was a wreck! HIPA came to the rescue with a replacement carb kit!
History: My neighbor asked me for help with a couple of abandoned Coleman KT196 Go Karts that she got for a killer deal. These Coleman KT196 Go Karts are rather common, and not very old. They were expensive when they were new, but parts are rather plentiful and not very expensive when it comes to the world of motorsports. Some time later they both ended up in my possession and now we've got something fun to work on!
⚫ Consider Supporting This Channel!⚫
GET MERCH ▶ duckshit.net/store
PATREON ▶ / duckshit
RUMANDCOLA FUND ▶ paypal.me/duckmancycles
⚫ More Popular DuckmanCycles VW Videos ⚫
⚫ 1967 VW Bus Restoration Playlist ⚫
Gregory ▶ duckshit.net/gregory
⚫ 1956 Chop Top VW Beetle Restoration Playlist ⚫
Eleanore ▶ duckshit.net/eleanore
⚫ Engine Stuff ⚫
Valve Adjustment ▶ • VW Valve Adjustment /...
Setting Static Timing ▶ • How to Set VW Beetle E...
Lift Engine/Engine Stand ▶ • VW Engine Stand - How ...
Replace Clutch Cable ▶ • VW Clutch Cable Replac...
Remove Crankshaft Gear ▶ • VW - Removing Cranksha...
⚫ Body / Rust Repair / Restoration ⚫
Remove Beetle Body ▶ • Body Comes Back Off - ...
VW Body Lift and Dolly ▶ • VW Body Lift / VW Body...
Reinstall Beetle Body on Pan ▶ • VW Beetle Body Put on ...
Bolting Beetle Body to Pan ▶ • VW Beetle Bolting Body...
Rust Conversion ▶ • Rust Conversion - ROTT...
⚫ Floor Pans ⚫
Replace Beetle Floor Pans ▶ • Replace VW Floor Pans ...
Replace Pans (Eleanore) ▶ • Floor Pan Replacement ...
Replace Karmann Ghia Pans ▶ • Replace VW Floor Pans ...
Replace Thing Floor Pans ▶ • Replace VW Floor Pans ...
Replace Type 3 Floor Pans ▶ • Replace VW Heater Chan...
Flip Floor Pan By Hand ▶ • Flip VW Pan by Hand
⚫ Electrical ⚫
Replace Dimmer Relay ▶ • Howto Replace Air Cool...
Hard Start Relay ▶ • Howto Install a VW Bee...
12v Starter Differences ▶ • 12V VW Starter Differe...
⚫ Brakes / Suspension / Drive ⚫
Tie Rod Replacement ▶ • VW Beetle Tie Rod End ...
Packing Wheel Bearings ▶ • Grease Packing VW Whee...
Lowering/Brake Upgrade ▶ • How to Lower your VW B...
Lower/Raise Rear Torsion Bar ▶ • Torsion Bar Removal/Re...
Flaring Stainless Brake Lines ▶ • Making Flared Stainles...
More Flaring Stainless Lines ▶ • Flaring Brake Lines - ...
Replacing Rubber Brake Lines ▶ • Air Cooled VW Rubber B...
Residual Pressure Valve ▶ • VW Rear Disc Brake Res...
Install Rear Disc Brakes ▶ • VW Type-3 Rear Disc Br...
Bleeding Brakes ▶ • How to Bleed Your VW B...
Pack/Install CV Joints/Axles ▶ • Drive Axles / VW CV Jo...
Replace Lug Studs ▶ • How To Easily Replace ...
⚫ Type 3 Specific ⚫
Remove Type 3 Engine ▶ • ASMR - VW Type-3 Engin...
Install Type 3 Engine ▶ • VW Type-3 Engine Insta...
Type 3 Dual Carb Linkage ▶ • Type-3 Dual Carburetor...
Type1 Trans Mount in Type3 ▶ • Custom VW Type-3 Trans...
⚫ DUCKMANCYCLES FACEBOOK GROUP ⚫
JOIN THE DISCUSSION ▶ / duckmancycles
⚫ FOLLOW MY SOCIAL MEDIA ⚫
FACEBOOK ▶ / duckmancycles
INSTAGRAM ▶ / vvtheduckvv
TWITTER ▶ / vvtheduckvv
⚫ MY WEBPAGE ⚫
GET EARLY ACCESS TO VIDEOS AND MORE: duckshit.net
⚫ SUBSCRIBE TO MY OTHER CHANNELS ⚫
SkeeterTheDuck ▶ / skeetertheduck
VvTheDuckvV ▶ / vvtheduckvv
DuckmanCycles ▶ / duckmancycles
Theme song (Gearhead) by Kevin MacLeod/Incompetech.com
Background song (Who wants to Party?) by Kevin MacLeod/filmusic.io

Авто/Мото

Опубликовано:

16 дек 2022

Ссылка:

Скачать:

Готовим ссылку...

Добавить в:

Мой плейлист

Посмотреть позже

Комментарии : 75

@DuckmanCycles Год назад

Bit thanks to HIPA Store! HIPA Store ▶ bit.ly/3W3RbG5 Carb ▶ amzn.to/3j1kUkq

@carllallemand5774 Год назад

I've used Hipa before and they never let me down. That looks like fun.

@DuckmanCycles Год назад

I gotta say, they've been good to us! Both as a reseller and a sponsor! You'll see more of them soon enough!

@jamesk3565 Год назад

Always awesome to see David in your videos. Talk about being lucky for a single pull start without adjusting anything!!!!

@ranchero302me Год назад

yes sir awesomeness time

@DuckmanCycles Год назад

Yeah, one pull wonder.... that thing was a disaster to start and keep running before. Now its just perfect! Ranchero302me ▶ ru-vid.com

@jamesk3565 Год назад

@@DuckmanCycles"One pull wonder" is that going to be David's nickname now?!?!?!

@PhilG999 Год назад

Every time I see those "tractor" chevron tires I'm reminded of a job I had years ago where one division (Deutz-Allis) made tractors and combines, and so on. Guys came over with all the shiny new brochures for their new model tractor. We just dealt with the engines. I'm sitting there with my boss (the Chief Engineer, I was Warranty Engineer) and four of the "Marketing" guys, took one look at the glossy cover and started laughing. Everybody looks at me and says: "What's so funny"? I said: "Nobody else sees what's wrong in that picture"? Nope. "The drive tires are on the wrong side! Any farmer that looks at will wonder what ELSE we did backward"! You see, the tires should be the way they are on that go-cart. They dig into mud and push it to the outside. Other way around and they load up with mud and you're stuck! I spent 8 years with that company, and I could write a book about the way customer's (and others) fucked things up! 🤣

@DuckmanCycles Год назад

Yeah, in rare occaisions you may find the tires on backwards, they provide a better digging aspect to some types of turf. Rather than shedding mud, they'll pack it in. But yes, they are correct as seen on the kart! Thanks man! Ranchero302me ▶ ru-vid.com

@PhilG999 Год назад

@@DuckmanCycles Yeah, that's the way to do them on sand. I'll never forget the time when I was little, and we went to Florida (Clearwater, I think) and I saw a firetruck with (as Pop explained) Aircraft landing gear tires on it! I guess in the swamps and sandy areas they needed the flotation and low ground pressure.

@DuckmanCycles Год назад

That's rather interesting. I'd like to see that.... in the swamp!

@PhilG999 Год назад

@@DuckmanCycles It must work. I've seen a few others over the years...

@HipaParts Год назад

Awesome video and amazed to see the one-pull start. I'm excited to see the go-kart revived.

@DuckmanCycles Год назад

Haha, he blasted it around over the weekend until the wheels flew off... LITERALLY! We'll be back with more repairs soon! Thanks so much!

@TaxedtoXXX Год назад

Happy you got a sponsor 👍🏻

@DuckmanCycles Год назад

Me too thanks so much!

@imbadwrench Год назад

LOVE redcoat... have used it on lots of sketchy shit.

@DuckmanCycles Год назад

Its even in Eleanore's tank! Works great! Love the smell! Haha!

@LetsGetPoppin Год назад

Hi Glenn, Another great video 👍,. Keep up the good work from Dave in Australia 👍.

@DuckmanCycles Год назад

Thanks so much Dave! It's awesome that we got it going so easily!

@johnlenoir1023 Год назад

Thank you so much for your videos thank you for all your information I never even knew about HIPAA I can't believe that it ran that good I have to check them out I have some old equipment I need work done too interesting thank you

@DuckmanCycles Год назад

Thanks John! HIPA has been good to us, you'll be seeing more of them soon!

@jeffgoswick7660 Год назад

Duckman thanks for the early morning video

@DuckmanCycles Год назад

And thanks for watching! There will probably be another Bus video tomorrow morning, too!

@youtubesavich Год назад

Genial amigo, un juguete para adulto👍👍👍

@DuckmanCycles Год назад

😁👍🦆💩

@MarkLoves2Fly Год назад

Fantastic @Lord Duckman's Cycles and Air-Cooled Garage Good stuff right there! What happens if you put a tiny carb like that on a 1600 VW engine? LOL

@DuckmanCycles Год назад

LOL we might find out.... reading my mind.

@MarkLoves2Fly Год назад

@@DuckmanCycles I love the idea! Yes! Make it happen! ✌️😁

@DuckmanCycles Год назад

I wanted to do that kind of thing anyway for years, but recently there's been a few other RU-vid channels that did similar things. 😁👍🏻🦆💩

@shartne Год назад

Needs a new tire and tube probably. I use to ride go carts with my son. All the kids like my carts. I like them to have a live axal so you can really go with out getting stuck. new tire so he can turn it needs grip.

@DuckmanCycles Год назад

Tire is worn out for sure... it's a tubeless! Might stick a tube in it if it still has trouble sealing but this week he got it to hold air... then the whole wheel came off lol! Thanks man!

@Yogenh Год назад

Hell you should put a motorcycle motor with transmission on it

@DuckmanCycles Год назад

YOU SHOULD! I'll probably do something like that on mine! More to come! Thanks!

@Yogenh Год назад

I think a nice 500cc should make it go

@smashingtriggerswiththerookie 5 месяцев назад

I got the same carb for my kt 196, it runs but won’t idle. Adjusted the idle screw. Still no idle. Help 😮 only runs when I have someone pull start it while I give it gas.

@stevenrennie2612 Год назад

A want to make myself a custom one just need old bike or quad engine as a donor and some parts

@DuckmanCycles Год назад

Yep! I'm looking for the perfect powerplant for my own. Maybe this winter!

@bradwiebelhaus7065 Год назад

High tech funnel.

@ranchero302me Год назад

Do what you gotta do on the fly

@DuckmanCycles Год назад

Yeah can’t beat it for the price! 😃👍🦆💩

@romano54321 4 месяца назад

I’ve got the same cart and I just cleaned the carb today. It started first pull with choke on. As soon as I let the choke off, the cart took off full speed. The problem is the throttle isn’t snapping back against the plastic throttle screw. The governor rod and spring are hooked up correctly to the throttle. Does the throttle plate have some sort of internal spring inside or is it supposed to flip back and forth easily if nothing is attached to it?

@DuckmanCycles 4 месяца назад

There's a lot of different Springs that go on the throttle, but I'm on certain which one you're missing or which one you need but that actually seeing it myself. Some of that throttle setup is more complex than it needs to be, but I'm not the one who designed it if you know what I mean LOL... but it doesn't hurt to add an extra spring!

@romano54321 4 месяца назад

@@DuckmanCycles I added a return spring on the governor lever and I fixed the problem. I drove the car for 1/2 hour but an old problem surfaced. Engine keeps dying but can be restarted right away. I ordered a new carburetor and installed it, but now engine only runs with full choke. Engine dies as soon as I take the choke off

@DuckmanCycles 4 месяца назад

If it dies with the choke off its definitely got some crud in it. Hipastore.com to the rescue!

@romano54321 4 месяца назад

@@DuckmanCycles actually I did install a new hipa carb, filter, hose, gaskets. Fuel tank is spotless also

@DuckmanCycles 4 месяца назад

The HIPA store is pretty awesome... they've been one of my recurring sponsors over here. I'm very thankful for them, and I'm very happy with their replacement parts!

@richardbrowne3641 Год назад

Great save with a new carburator! One pull? Incredible! Goto RU-vid Channel Cars & Cameras. They do small engine builds that are crazy!

@DuckmanCycles Год назад

Yeah I still can't believe one pull.... lol! I figured for sure it would need more adjustments or maybe even a fouled plug! Ranchero302me ▶ ru-vid.com

@mortneff4674 Год назад

What no link for Ranchchro??

@ranchero302me Год назад

it me yeeehawww

@DuckmanCycles Год назад

Why not look! Hehehe! Ranchero302me ▶ ru-vid.com

@user-ro7bb6bm7g Год назад

Yeah but a go-kart the same same go-kart there I bought a go-kart like that I was going to sell it I was wondering how much you think it would be worth couple hundred 300-500

@DuckmanCycles Год назад

On the low end, yeah probably. I see them listed for around $800-$1000 on marketplaces for ones in good condition. A new one is about $1300 and up.