Volvo I-shift failure. What to know. 

In January 2020 I had roughly 490, 000 miles on my I shift volvo transmission when I finally took it into the Bakersfield, ca dealer for repair. They covered parts, and labor under warranty and I paid I close to $1700.00 for the brand new clutch and flywheel resurfacing everything but those items were under warranty. Turns out I had a bad clutch actuator and a bad air leak, but month later as I was at 498,000 miles I took it back in because of more issues and they ended up replacing the whole case with a new one and repair was close to 10k warranted. THE WAY I SAVE MY CLUTCH IS BY STARTING OFF ON 1ST GEAR ALL THE TIME AND BABYING THE TRUCK UNTIL IM IN 11TH OR 12TH GEAR. Check your transmission oil by looking at your sight glass frequently.

A bad carrier bearing causes the rear range synchronizer to fail. And all the ishift/mdrive transmission come with silicone on the back box and bell-housing from factory they do not use a gasket. Only paper/metal gaskets are on the top cover.

How much to rent Jose?

Here in Brazil they have a lot of volvo top

I change transmission filter 2x a year every 6 months and once a year in may before hot summer. Fresh air dryer assembly in november before winter and every 3 months the air dryer filter only. Never had problems. 650k miles

Hay my 2023 volvo vnl 860 has the same problem. It doesn't have more than 252k miles on it now but the notice of ; CHECK THE TRANSMISSION ON NEXT STOP popping up constantly here and there sometimes and it's been 3 days. Please help me to take care of it

Where are you giys located?

Hello I have a question, I have a volvo d13 2011 automatic I shift, I have problems sometimes it is working well and suddenly it goes to neutral and does not want to take changes, I have been told that it does not transmission, it may need some programming in the model of control? please help!! thanks for your video and I wait for an answer I am desperate to fix my truck

A Volvo d 13 or 14 if you have a price like average of the fix the transmission

Hi TRUCK YOO/SEBASTIAN, I JUST DISCOVERED YOUR CHANNEL YESTERDAY AND SUBSCRIBED BECAUSE I AM LOVING IT. I SAW YOU DRIVING SCANIA IN POLAND IN ONE OF YOUR VIDEOS. PLEASE,BETWEEN VOLVO D16 ENGINE(WHICH IS STILL AVAILABLE IN EUROPE) AND SCANIA S730 ENGINE WHICH IS THE MOST RELIABLE/BEST. THANK YOU IN ADVANCE.

My transmission sometimes failed to shift each time it changed from E to L.

Is it hard to convert to a 13spd Eaton?

You said what to know in title but did not provide anything to help in this video that we should know very low explanations

Remember, I really don’t care for the Volvo trucks, but it sounds like the shop cut some corners. What a shame! So what has your customer decided? Yeah, cutting corners doesn’t usually work out in the long run, and usually not even in the short run. Do you know what shop he took it to? Should he consider going back to them so they can have a chance to make it RIGHT? Well, it was just a quick thought. Enjoying what you do! 🤩

how can I contact you for more research not on RU-vid or Instagram

Don’t cry, Buy scrap 6k that’s it. Without to much talking

The I shift it could be grease?

Where can I send my transmission to get it rebuilt ?

How much cost a input shaft with bearings replacement?

I'm using manual sir,if I engage 7 gear it has a sound, other gears are ok.what is the common problem?

I replaced mine at 750k reman trans plus brand new TCU. I have 955k right now original clutch still on there .

I have a 2016 Volvo 780 with 410k miles the other day so turned it on it said transmission low air supply. What does that mean?

I having same issues I replaced the clutch and now it won’t go into gear sometimes.

🤔... 🧐 How many miles should you expect to get out of an I-SHIFT❓ 😒 😜🤑👹💰🇺🇸

what is best semi for rv, puller ?

Hi, I am from the Chicago area and have Ishift problem. Where are you guys located? My issue is my transmission in limp mode, starts out in 5 gear. what are the possible causes?

Any chance you can show how to remove the control housing? I struggle to remove those.

Hi I look you videos I'm desesperate I have 2014 mack pinnacle mdrive transmisión I buy it 2 weeks ago and since I buy it when you drive i start sometimes between gear change rpm go up and don't accelerate after a week a was taking to mechanic and rpm go up and truck dont accelerate and I have to stop for like 20 minutes onto I get gears and start diving again and keep doing it over and over ..and sometimes rpm don't even move and truck dont accelerate but if you turn it off for like 20 minutes I drive back again...I yes send you this message maybe I case you no know what it is or something anything help thk so much and God bless you ❤..keep trucking

Do you flush the transmission fluid lines

It goes forward not backwards

I really wanna be a Volvo mechanic like Jose

Where is your shop guys located I was wondering I have a problem with the i shift

that is a very common failure the syncro and range cone can be serviced as long as input shaft is not loose

Like how much is the coast of roaring the transmission??

How can I reach you guys

how many miles should change transmission oil or its not recommended?

He doesn’t even know wow.

Am in Florida and I can’t find a shop to rebuild my Volvo transmission

Hi, I’m starting to have more problems with my I shift, and it show check transmission next stop, when I’m driving reverse in gagging when I press gas pedal soon I release truck pulls forward and truck doesn’t want to go reverse when I press gas pedal! Even forward sometimes too, Is better to rebuild and how much cost? Or baying a used one? Thank you

Heyyyyy

Lovely 😍💋 💝💖❤️

Vídeo excelente mais um inscrito

I'm driving a 2017 Volvo Trac iShift semi truck and my truck came to a complete stop on the highway this morning .. I was doing 60mph with a fully loaded 53' trailer and it came to a complete stop fast without skidding.. Complete stop and seized up for a few min would not move..;No air leaks.. plenty of air in the tanks.. I turned it off and back on a few times set and released the brakes a couple times and all of a sudden it just released and I was able to continue driving.. Please help.. What caused this.. It was 30 degree's outside not that cold???

i shift is a great transmission providing you drive the truck like a very old man would

I-shift is not good