International 4300 DT466 Cold start 

I drive a bus with a DT 466 and I have found the best way to cold start is to cycle the pre-heaters four or five times before cranking the engine. She always goes.

put a hot plate 1"below the oil pan ,and put a trickle charger on a battery .plug them in 1 hr before starting and it will start .the warm oil will allow the motor to spin over faster .

Lucky man in the driver's seat. Definitely a lucky man.

Great video. Kyle

Block Heater = Longevity

I used to drive an International concrete mixer,powered by a mechanical DT-530,300hp. Never had any issues cold starting that thing. That old truck would be loaded and on the way to a job, while the other drivers were trying to start those new gee-whiz,electronic M-11's.

This 02 looks like a 2018 straight gorgeous

I drive the 2006 international 4300 dt466 everyday. Yours looks identical inside. But I don't have any trouble in the winter like you did. I live in Newfoundland Canada 🇨🇦 it does get cold here, never seen anything like this before. I hope your truck is still running ✌

that tuck some getting started, ( now all I need is the heater on yay)

I drive an '87 and a '97 International with the DT 466 and 466E respectively. NEITHER has a block heater and NEITHER have glow plugs. Both start not bad in the cold but the older one bucks, chucks burps and farts while trying to warm up. only once in very cold weather did it fail to start.

You need to have 12-14 volts if you wish to start a massive vehicle such as this one.

That battery voltage is dropping off way to much I know its cold as hell but still

I LOVE THE GAGES

@aeastman16 hydraulics need power to operate, so the truck had to be running in order to build up pressure. same and oil pressure, light will show before the truck is running and wont go off for a couple seconds after it is turned on

wooooooowww amazing baterry!!

I have this same problem with my international huge huge problem getting it started

nice truck

Nice Audi!

Hold the panel up/down switch(Next to headlight switch) and trip switch at the same time. That beep will stop till its started or key is cycled...

Little trick i use to start our transit truck which has no heater is to get an old peice of flexy hose from an old hoover stick it on the exaust of the tractor or car and shove it under the bonnet. Few min of that and shes away.

Seems like International needs to start making engine block heaters standard equipment.

U need a block heater AND a coolant heater like A Wabasto if you gonna start in the cold.... maybe some ether too

you should cycle glow plugs or what ever this truck have two three times and crank it. Great Video

Mine starts like that in the summer.

Current Maxxforce is basically a relabeled DT, just built to comply with the current emissions standards.

Mine fired right up at -38F windchill. Cycled it twice. Grid heater no plugs.

Alright it took some effort but you finally got her to fire up

@Johnny64ism ohhhhh yea good thinking, how could I have forgotten to plug in the block heater... oh yea it doesn't have one...

0:43 0:53 I like the sound of the old preheaters & the old alarm noise in it

Oh what an old vid 😮 Getting that bear out of hibernation was a real challenge. Nowadays u can get an affordable heating pad that attaches and unattaches quickly for underneath the oil pan.

only use ether once the wait to start is out and starts to crank over, she will back fire ether out the air cleaner if not careful. the wait to start is a air/grid heater in the air intake manifold. sometimes they fail, and super hard to start..the 466 is a HEUI engine hydralically actuated unit injector.basically oil pressure driven injectors.needs a volume of oil to activate injectors.which also makes it hard to start. basic help is heat, and always is heat for any diesel in cold temps.

Nice Audi ;)

When she started to fire on the 2nd to last attempt before the battery died, if you had kept cranking she probably would have started. Getting heat into the cylinders is the key to starting a diesel this cold. At that point she was making heat, you just had to keep going. As soon as you stop the heat stops too. Don't be afraid to use a little throttle too. Once the engine is at a certain RPM the throttle control is given to the driver rather than being held back so that can force a bit more fuel in to give it that final kick into starting. If she's lumpy at idle hold the throttle open to give her a bit more revs (200rpm more than idle) and it'll smooth out in no time. Bring back the indirect injection engines without the electronic crap, they'd start in anything with a good set of glow plugs! =)

Nice

You should have cycled the grid heaters a few times before attempting to start it. When ever its below 0F out i have done that with my Cummins. always fires up. Them internationals are a pia in the cold.

i work for internation , the 466's we hard starts any colder then -15, even worse in -40c if we had a no start when cold block heater and tiger torch on the oil pan until the oil was warm, international called for 15w40 all year long..warranty would be void if it wasnt 15w40.other then ether is about the only way to keep it turning over until enough heat is produced to take over. if she doesnt start on the first go at it stop and heat her up, she will go after about 10 min of a tiger torch.

thickened oil makes it hard to build icp up. the oil in the hose between the hpop and the head has to be damn near tar that cold.

imagine having to do this every morning for about 6 months

There is a good possibility the oil rack in the head is leaking oil and the high pressure oil pump is having trouble building pressure to fire the injectors…in any case if my truck was hard starting like that I would be plugging it in even for just a half hour..be better than cranking the crap out of it!..

Yup

Wow, it came really close to firing up without charger help......

Lol i drive a dump truck almost identical to this, once it starts turning faster pump the gas pedal a couple times and she will fire right up.

I have the same issues every winter ,,, why dont you plug it in?

He should've done the glow plug dance!

How is this a DT and The wait to start light is on?

Come on baby, come on you can do it, Come on Come on

Which yere was the truck and how many miles did he have?

need to invest in some either.

4k rpm?

@renaultbaccara Its a 2006 with about 50,000 miles

has to crank at atleast 250rpm to start. It was doing 100rpm. you tear up the starter when you try to start it with a dead battery. Lots of amperage and low voltage messes it up.

intake air heater?

1°F ? Have no idea if is up or down 0°C

@BobcatNinja2124 I would point out that you should have hooked the battery charger up first... that comes from 8 years of living in Alaska... once you hit -20℉ you just kinda assume the battery is going to be killed by cranking :-p heck I used a booster even after leaving the block heater going all night (I know you don't have the block heater), it just helps prolong the life of your expensive equipment :-)

How to start my its been giving hard starting for long now

Is that the 466 or the 466E?

I wonder why does the Tach go up to 4000 RPM even though International uses diesel applications why does it go that high up?

left up, right down...on your cruse control buttons...push and hold left up and push and hold right down at the same time...this will give you an ERROR reading. Let it run a system check then turn your left turn signal on and push both buttons up at same time and hold. This should help clear out ERRORs. Keep key in on position and park brake on.

@aeastman16 even inf hydraulic systems, on a truck this big, there needs to be a pump that puts artificial pressure in the system, there's no way you could make that kind of pressure just by pressing the brake pedal

Peace out starter.

can you show where the coolant temp sensor is located on a 2005 4300? thanks

what year is it?

you need like just under 12 volts to start the engine i find cycling the engine twice bumps up the voltage dont ask me why lol.

С пуско-зарядным можно стартёр хоть сколько гонять ))) надо было просто 3 раза погреть свечи

You'll get more pissed if you had to listen to a Freightliner M2 low air warning, mo beep but just a loud constant beep.

fries are up.. lol

Direct injection engines really do hate that cold! I have an IDI diesel that starts at 5F on 1 turn. No doubt it would do the same at -5F too.

@Hydro022 Btw it was -20 Celcius.. so.. idk what that would be in Farenhieght

or does it mean the engine is idling off?

Starters hate lower power conditions, ragging on the starter till it will hardly spin doesn't actually help friend. I've replaced enough doing that same thing myself.

Internationals have issues with the cold.. Friend of mine drives one with the tow company he works for, just an international 4300 boom truck, sat all night at -20, 5 hours of cables from another truck AND the block heater, wouldnt start. Finally cops got bitchy we had to pull start it in 4th Gear for it to go.

shouldn't it fire up first time.I know its cold but its a fairly new truck.maybe use better anti freeze our a good tune up and service. but its a cool truck.

Ha ha...I love sarcasm when it is used in the proper way...this one was, lol...

personaly i hate grid heater or glow plug it just kil the battry befor u try to start some brake cleaner insted on ether starting fluid do the trick pretty well and it run smother then ether

Where is the air gauge

good thing it wasnt a maxxforce!! youde be there till the snow melted

does that BEEEEP BEEEEP BEEEEP mean the battery is dying?

why didnt you cycle your glow plugs a few times to warm up the cylinder

Why is the brake pressure light on if you've got hydraulic brakes?

is that your owen company

At 4:30 almost started

Thinks its time to invest $44 in one though

Can tell it doesn't have enough battery to start just by looking at the gauge.

I'm pretty sure a diesel would be a PITA to start no matter what country it's from.

In what car did you sit in the beginning of this video? Looked familiar. Audi?

from 2005 diesels have glow plugs from 2005

me deu ate cansaso so de ver, acho q vou na garagem dar uma ligada no meu carro agora.

Nace

Looking for opinions on using an 2008 International 4300 ambulance DT466 for an RV conversion. A lot of Internationals out there cheap. Wanting a Freightliner but hard to find and more expensive. Should I settle?

11.6 mpg in that little car? geez

MAXXFORCE DT 466 is a Mercedes BENTZ E390T

Hearing that beep in the morning... :-/ By the way, what is the sound that the truck produces while not started yet??

You will be replacing your starter and batteries before long !

Not sure if all that smoke is the engine or your starter. HaHa

nice to give me the laugh LMFAO

Webasto heater.. and that starter is done

Yeah, -1F = -18C.

Help axcilator m daily start I have shame truck

@TjMerrigan11 Its my families company

:)