Hammer mod TDI VE Injection Quantity adjustment, VCDS adaptation 

This is awesome, thank you. I'm due for a fuel filter change. I'll see if that fixes my issue and if not I know what to do.

great vid. it made my setup that much easier to do.

The bolts you released are just for the lid. All except the special bolt. It goes further down. It is the lower boots you are supposed to loosen, and then iust tap the pump very slightly.

Молодец!

Good video Once you get it close to your setting MANUALY you can change it using the Ross Tech cable , it will be stored in your ECM ,My 1.9 TDI Ross tech program will only take it down to 3.5 so I have to adjust it manually ! {Take it down more at the pump} ,Then fine tune it with the Ross-Tech program HEX-V2 ! Hope i make sense

Corect...👍

Great video. Andrea Manae had a good question. What would you consider the best numbers for fuel economy? Not looking to add more power. I have a 02 ALH Jetta TDI wagon. Thanks

hi cheers for the vid!, out of interest have you put bigger injector nozzles in or you keeping them the same?, cheers

Hi dude,please tell me how did you connect your tablet with the car? What operating system in your tablet running,android or windows?

Will an incorrect injection quantity adjustment damage the engine or is it a drivability tuning issue?

i have a hard start on my 2002 vw jetta tdi , car will only start up if i plug my frostee heater up please help temps in NY have been around 25 degrees and below

What are the symptoms of the timing being out at the pump? I mean can a person just drive a vehicle with ALH in it and tell that the pump’s timing is out? I don’t have VCDS but experiencing loss of power ,hence the question

What kind of computer are you using? Great vid btw

Saw some of your videos how do you the vcds program I got 2 jettas tds

Is 94.5c normal temperature? Mine used to sit at 90c 92c after a hard drive , after changing the thermostat it now sits at 93c to 97c driving hard uphill does this seem normal?

What fuel filter setup are you running?

Hi, what's the vehicle and tdi engine and year.. cheers good video 👍

Hi. Vw polo 1.9 sdi. 2005. What should the lower range be? And what should the higher range be please. I am getting the N146 lower limit reached. Any help is welcome please

Hi can i do this on audi a4 2.0 tdi pd 2006 my car is shaking at idle and injection quantity bouncing around 1.5 to 2.5 mg/str

Hello I hope you still read the comments :) I have a golf 4 1.9tdi ALH (90hp) with cat delete and egr delete also stage 1 tune. What should be my IQ? What is the normal for this setup? Also I want to upgrade my nozzles to .216 nozzles when I upgraded it should I upgrade my IQ to? and what should it be. I hope you answer. Thank youu :)

My injection quantity is 11 mg/str, 1.9 tdi pd engine. What can be the problem?

Will this solve the limp mode of tubro or faulty injection pump if the codes are shown. I have EGR delete.

You're supposed to loosen the bottom bolts, not the top ones.

It's the top piece???! FML! I marked the bottom section, not the top one when I took it apart and that's what I've been trying to adjust! Holy guacamole I am an imbecile! It's 4AM right now, got the battery trickle charging, I am excited AF to get out there and hopefully fix my car! I don't have the software, I can only start it with ether and it won't rev past 2k RPM at WOT. Virtually zero power if you try to actually move the vehicle it just dies.

Can i adjust injectiin quantity without the hammer mod?

what is the best IQ number for fuel economy? thanks

Can you change the numbers without doing the hammer mod?

Hello I hope you still check the comments my IQ is at 20mg and that’s at running temp I just swapped my 10mm pump out to an 11mm and I’m getting the 20mg reading with the new pump in. If anyone has any ideas please lmk

Will I be able to do this with the VCDS LITE version, not the free one but the $99 one ? My IQ is showing 12 mg/str in the free VCDS version. My 03 ALH is blowing a lot of white smoke. I already changed a bad turbo with bad fins and leaking oil. I'm assuming the car had a runaway because all the charge pipes and the EGR were soaked in oil. I just got the car 3 weeks ago for $1250. 190k miles.

How do i get The adaptation cod on my mk3 tdi

Can it be done without vcds? If so how can i find its near to 3-4?

Can you give some details on that fuel filter setup?

I've got mod out the ass never used vcds just a custom tune flashed what's the purpose of this hammer mod less or more fuel if it's more fuel any draw backs also y is it needed if it's less I understand I have 230 injectors I'm on my 3rd turbo lol car won't seem to run less than 30 psi at wot no matter wtf I do

Pleeeeeaaase someone explain me for gospd sake iv been watching lots of people saying that if the number of injection quantity is lower it gives you more power because it injects more fuel . BUT HOW A LOWER NUMBER CALLED INJECTION QUANTITY IT INJECTS MORE FUEL i mean it doesnt make ANY SENSE

Please someone reply me here, i need help, i measured the resistance on the pump conector, the pins 5-6 and 2-3 are correct resistance but 1-3 is out, not between 4.9 to 7.5 ohms, its showing 12ohms, so based on this manual service is saying to Replace pump, i put too much money on this stupid car, and i just lost my Job, can’t afford the crazy price of a new pump neither afford to pay for someone do the pump replacement. I am driveway car worker, iam not mechanic neither got the tools to pull the engine off, if id had to take pump off and mess up with all the timing belt stuff i could mess up it more.

I need more fuel= more power I have stage 1 but i need more fuel What i want lower iq or ?

is this for real ?

híí my car alh 1.9tdi stage1 how much ideal? I want to many big smoke?

Higher the number more fuel or vice versa? I heard different opinions...

Come on is that for real?

so why is it good for us?

This a joke right?