How to Uninstall and Install the Gas Tank of a Kawasaki Vulcan S 650 

Had an issue with indicators not working (tested with 9v batt, no issues). Everything else working fine except for a blown headlight bulb. Didn't check fuses because I figured other stuff wouldn't work if it were a fuse issue. Figured I'd knackered a wire under the fuel tank when I was putting in heated grips, so I follow your instructions - which are fantastic by the way - nothing. Figure I might as well check the fuses. So now I have some 10amp replacement fuses arriving tomorrow. What a saga.

I have a 2019 vulcan s I wrapped with plastics on stupid hard. Now thanks 2 u I can wrap with no plastics on ty so much.

thank you for sharing! i installed the booster plug and air filter without having to remove the tank, but by just moving it around. would have been much easier to remove the tank and get the benefit of space.

Great guide :)

Thank you the video help alot!!!

Thank you for this Video!!! I must Airbrush the Gastank from the VulcanS from my Girlfriend and i must install the Gastank for this!!

Nice job done

Thank you so much!

I see you mark the breather hoses in your video very smart. Mine are not marked and I’m not sure which way to connect them. I have the blue dot on the tank, does the hose with the blue dot run down under your bike and come out by the kickstand? Any help would be greatly appreciated. Great video

Nice videos I learned a lot. Can you do a video on how to change out the motorcycle grips

Hi Nathanael, I Have also Vulcan S and when I was in my garage and I was replacing air filter I had feeling, that the gas tank was little presurized. The reaseon was, that I was heating my garage. And every few minutes I heard noise of the tank like it was releasing gases...... I think it was becouse of increasing temperature in the garage and increasing of presure in the tank...... My question is - is it possible to disconect those two lines from the tank and put some pressed air into them? I think one of them should be "waste line" and the other one should be returning from fuel pump. Do you know which one is the waste one ? I think one of them goes down and it ends somewhere close to kick stand......... That could be those "waste one", or those wich can overflow some fuel when you overtop the tank....... I think this one can be stucked and thats the reason why my tank get overpresurize when it is getting hot....... Thanks for your answer......

Love your videos! Did you change your sparkplugs yet on your vulcan S?

El video está bastante bien pero hay ciertos detalles que conviene aclarar. Es conveniente vaciar la gasolina del tanque obviamente para quitarle peso. No va a fugar gasolina del tanque porque la bomba de gasolina hace de obturador. por tanto cuando se suelta el acoplamiento de la manguera de la gasolina sólo salen unas gotas como se ve en el video. Yo he cortado las mangueras de goma del respiradero y desagüe y he instalado unas espigas macho-macho de 6 mm de diámetro para unirlas nuevamente, con ello facilito mucho la labor de extraer el tanque y no me arriesgo a dañarlo al no tener que andar manipulando esas mangueras de goma con sus grapas, etc..con el tanque de costado de mala manera. Suelto previamente de las espigas y levanto el tanque con unos tramos cortos de manguera sin mayor problema. Me parece un mal acabado no haber previsto esta maniobra por parte de Kawasaki con lo fácil que resulta colocar unas uniones. En fin, para que lo tengais en cuenta.

Me surge una duda, parece obvio pero, ¿es necesario vaciar previamente el depósito de gasolina? Gracias.

I wish I had found this video before I installed the new air filter. I didn't know I could disconnect the gas pump connector (at 7:50), wish I did. Somehow the tank touched something (I suspect it was the positive side of the battery) while reconnecting the breather pipes and one of the cables on the connector heated up and the insulation got burnt. Lot of smoke for a couple of seconds. The motorcycle turns on but I better find someone to replace these cords asap.

Where did you get you passenger seat?

Does the tank have to be empty

Podías ablar en español..por favor ..porke tú eres español..

Able usted en español

Able usted en español